Repairing the exhaust development on your 2003 Kia Spectra Testament not crave any specialized Accoutrement as all the components bolts in sync. There are three higher parts that Testament devoir to be inspected or replaced. The first--and most expensive--is the catalytic converter, followed by the mid muffler then the Ending muffler--also referred to as the resonator. Everything is held in domicile by rubber hangers that snap over metal tangs.
Instructions
1. Up thrust the automobile with a jack and deposit jack stands under the front domination arms then lower the automobile. Position rear jack stands under the pinch weld on the unibody frame and grant the lower axle to Blop. This Testament construct Emigration and installation of the rear-most muffler and tailpipe easier.
2. Peep the exhaust development for holes and leaks. These should be obvious, nevertheless, provided longing be, dawning the machine and from underneath listen for the aim of the leaks. Identify the environment and allow the car to cool before proceeding. Spray aerosol lubrication onto the retaining nuts of each component that will be removed. Allow the liquid to soak in for 10 minutes.
3. Loosen the two front bolts and two rear bolts with a 3/8-inch socket and wrench then remove the fasteners. Remove the converter or muffler with a large screwdriver to lever the rubber mount off of the metal tang that holds the part in place. Use a wire brush to scour the mating surface, install new gaskets, then place the new muffler or converter into position. Test-drive the car to be certain there are no exhaust leaks or rattles.
Install and tighten the mounting bolts then lever the rubber mounts back into place.4. Start the vehicle and check for exhaust leaks before lowering it to the ground with the jack. If leaks are present, repair them.
